NIF WATERBASE EPOXY PART B COLORS
PRODUCT NAME: NIF WATERBASE EPOXY PART B COLORS
HMIS CODES: H F R F
PRODUCT CODE: 015 B 1* 1 0 B
HMIS CODES: H F R F
PRODUCT CODE: 015 B 1* 1 0 B
SECTION I -- MANUFACTURER IDENTIFICATION
MANUFACTURER'S NAME: NORTHERN INDUSTRIAL FLOORING, INC.
ADDRESS: 8140 W 350 N ANGOLA, IN 46703
EMERGENCY PHONE: CHEMTREC 800-424-9300
INFORMATION PHONE: 800-424-8914
DATE REVISED: 01-01-97 NAME OF PREPARER: HARRY JACKSON
ADDRESS: 8140 W 350 N ANGOLA, IN 46703
EMERGENCY PHONE: CHEMTREC 800-424-9300
INFORMATION PHONE: 800-424-8914
DATE REVISED: 01-01-97 NAME OF PREPARER: HARRY JACKSON
SECTION II -- HAZARDOUS INGREDIENTS/SARA III INFORMATION
OCCUPATIONAL EXPOSURE LIMITS VAPOR PRESSURE WEIGHT
HAZARDOUS COMPONENTS CAS NUMBER OSHA PEL ACGI TLV OSHA STEL mm HG @ TEMP PERCENT
----------------------------------------------------------------------------------------
Modified Diglycidyl Ether of Bisphenol A 25068-38-6 none none none 1.0 356F
Alryl Glycdidyl Ether 68609-97-2 none none none N/A
*** No toxic chemical ( s) subject to the reporting requirements of section 313 of title III and of 40 CFR 372 are present.
HAZARDOUS COMPONENTS CAS NUMBER OSHA PEL ACGI TLV OSHA STEL mm HG @ TEMP PERCENT
----------------------------------------------------------------------------------------
Modified Diglycidyl Ether of Bisphenol A 25068-38-6 none none none 1.0 356F
Alryl Glycdidyl Ether 68609-97-2 none none none N/A
*** No toxic chemical ( s) subject to the reporting requirements of section 313 of title III and of 40 CFR 372 are present.
SECTION III -- PHYSICAL/CHEMICAL CHARACTERISTICS
BOILING POINT: 200 Deg F SPECIFIC GRAVITY (H2O=1): 1.1
VAPOR DENSITY: N/A EVAPORATION RATE: N/A
SOLUBILITY IN WATER: NEGLIGIBLE
APPEARANCE AND ODOR: Low viscosity liquid - clear
VAPOR DENSITY: N/A EVAPORATION RATE: N/A
SOLUBILITY IN WATER: NEGLIGIBLE
APPEARANCE AND ODOR: Low viscosity liquid - clear
SECTION IV -- FIRE AND EXPLOSION HAZARD DATA
FLASH POINT: 200+F METHOD USED: SETA FLASH
FLAMMABLE LIMITS IN AIR BY VOLUME - LOWER: N/A UPPER: N/A
EXTINGUISHING MEDIA: FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
SPECIAL FIREFIGHTING PROCEDURES
DO NOT ENTER CONFINED FIRE AREA WITHOUT FULL BUNKER GEAR INCLUDING A POSITIVE PRESSURE NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS. COOL ALL FIRE EXPOSED CONTAINERS WITH WATER.
UNUSUAL FIRE AND EXPLOSION HAZARDS
NO UNUSUAL FIRE HAZARDS KNOWN,
PART B 015B
FLAMMABLE LIMITS IN AIR BY VOLUME - LOWER: N/A UPPER: N/A
EXTINGUISHING MEDIA: FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
SPECIAL FIREFIGHTING PROCEDURES
DO NOT ENTER CONFINED FIRE AREA WITHOUT FULL BUNKER GEAR INCLUDING A POSITIVE PRESSURE NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS. COOL ALL FIRE EXPOSED CONTAINERS WITH WATER.
UNUSUAL FIRE AND EXPLOSION HAZARDS
NO UNUSUAL FIRE HAZARDS KNOWN,
PART B 015B
SECTION V -- REACTIVITY DATA
STABILITY: STABLE
CONDITIONS TO AVOID: AVOID EXCESSIVE HEAT OR OPEN FLAMES.
INCOMPATIBILITY (MATERIALS TO AVOID): CAN REACT VIGOROUSLY WITH STRONG OXIDIZING AGENTS AND SRONG LEWIS ACIDS OR MINERAL ACIDS.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS: CO2, ALDEHYDES, ACIDS. REACTION WITH SOME CURING AGENTS CAN GENERATE LARGE AMOUNTS OF HEAT.
HAZARDOUS POLYMERIZATION : WILL NOT OCCUR
CONDITIONS TO AVOID: AVOID EXCESSIVE HEAT OR OPEN FLAMES.
INCOMPATIBILITY (MATERIALS TO AVOID): CAN REACT VIGOROUSLY WITH STRONG OXIDIZING AGENTS AND SRONG LEWIS ACIDS OR MINERAL ACIDS.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS: CO2, ALDEHYDES, ACIDS. REACTION WITH SOME CURING AGENTS CAN GENERATE LARGE AMOUNTS OF HEAT.
HAZARDOUS POLYMERIZATION : WILL NOT OCCUR
SECTION VI -- HEALTH HAZARD DATA
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
NO GUIDE FOR CONTROL KNOWN, HOWEVER, EXPOSURE TO HEATED VAPORS CAN CAUSE IRRITATION TO THE NOSE, THROAT OR MUCOUS MEMBRANES.
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE
SKIN: MAY CAUSE IRRITATION OR ALLERGIC SKIN RESPONSE. EYES: MAY CAUSE IRRITATION, BUT NO CORNEAL INJURY IS LIKELY.
SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
NOT LIKELY TO BE ABSORBED IN TOXIC AMOUNTS.
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
THIS MATERIAL HAS A PROBABLE LOW ACUTE ORAL TOXICITY.
HEALTH HAZARDS (ACUTE AND CHRONIC)
EPOXY RESINS CAN CAUSE SENSITIZATION BY EXPOSURE THROUGH CONTACT OR HIGH CONCENTRATIONS OF VAPOR. EYES: INJURY IS UNLIKELY BUT STAIN FOR EVIDENCE OF CORNEAL INJURY.
CARCINOGENICITY: NTP? NO IARC MONOGRAPHS? NO OSHA REGULATED? NO
NO CONSTITUENTS OF THIS PRODUCT ARE REGULATED AS CARCINOGENS UNDER OSHA, IARC, OR NTP PROGRAMS.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE
RESPIRATORY CONDITIONS OR OTHER ALLERGIC RESPONSE.
EMERGENCY AND FIRST AID PROCEDURES
EYES: FLUSH EYES WITH WATER FOR AT LEAST FIFTEEN MINUTES AND CONSULT A PHYSICIAN. SKIN: SKIN CONTACT WILL NORMALLY CAUSE NO MORE THAN IRRITATION BUT WASH AFFECTED AREA WITH SOAP AND WATER AND REMOVE CONTAMINATED CLOTHING PROMPTLY. INHALATION: REMOVE VICTIM TO FRESH AIR AREA AND ADMINISTER OXYGEN IF NECESSARY. INGESTION: LOW IN TOXICITY, INDUCE VOMITING ONLY IF LARGE AMOUNTS OF MATERIAL ARE INGESTED, OTHERWISE DO NOT INDUCE VOMITING. IN EITHER CASE IMMEDIATELY CONSULT WITH A PHYSICIAN.
PART B 015B
NO GUIDE FOR CONTROL KNOWN, HOWEVER, EXPOSURE TO HEATED VAPORS CAN CAUSE IRRITATION TO THE NOSE, THROAT OR MUCOUS MEMBRANES.
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE
SKIN: MAY CAUSE IRRITATION OR ALLERGIC SKIN RESPONSE. EYES: MAY CAUSE IRRITATION, BUT NO CORNEAL INJURY IS LIKELY.
SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
NOT LIKELY TO BE ABSORBED IN TOXIC AMOUNTS.
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
THIS MATERIAL HAS A PROBABLE LOW ACUTE ORAL TOXICITY.
HEALTH HAZARDS (ACUTE AND CHRONIC)
EPOXY RESINS CAN CAUSE SENSITIZATION BY EXPOSURE THROUGH CONTACT OR HIGH CONCENTRATIONS OF VAPOR. EYES: INJURY IS UNLIKELY BUT STAIN FOR EVIDENCE OF CORNEAL INJURY.
CARCINOGENICITY: NTP? NO IARC MONOGRAPHS? NO OSHA REGULATED? NO
NO CONSTITUENTS OF THIS PRODUCT ARE REGULATED AS CARCINOGENS UNDER OSHA, IARC, OR NTP PROGRAMS.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE
RESPIRATORY CONDITIONS OR OTHER ALLERGIC RESPONSE.
EMERGENCY AND FIRST AID PROCEDURES
EYES: FLUSH EYES WITH WATER FOR AT LEAST FIFTEEN MINUTES AND CONSULT A PHYSICIAN. SKIN: SKIN CONTACT WILL NORMALLY CAUSE NO MORE THAN IRRITATION BUT WASH AFFECTED AREA WITH SOAP AND WATER AND REMOVE CONTAMINATED CLOTHING PROMPTLY. INHALATION: REMOVE VICTIM TO FRESH AIR AREA AND ADMINISTER OXYGEN IF NECESSARY. INGESTION: LOW IN TOXICITY, INDUCE VOMITING ONLY IF LARGE AMOUNTS OF MATERIAL ARE INGESTED, OTHERWISE DO NOT INDUCE VOMITING. IN EITHER CASE IMMEDIATELY CONSULT WITH A PHYSICIAN.
PART B 015B
SECTION VII -- PRECAUTIONS FOR SAFE HANDLING AND USE
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED
WEAR RESPIRATOR AND PROTECTIVE CLOTHING. SHUT OFF THE SOURCE AT THE LEAK, REMOVE EXCESS WITH VACCUM TRUCK AND TAKE UP THE REMAINDER WITH AN ABSORBANT SUCH AS CLAY AND PLACE IN DISPOSAL CONTAINERS. FLUSH AREA WITH WATER TO REMOVE RESIDUE.
WASTE DISPOSAL METHOD
DISPOSE OF THE MATERIAL IN A WASTE DISPOSAL SITE IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL LAWS.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
STORE IN COOL DRY PLACE. SEAL ALL PARTIALLY USED CONTAINERS, WASH WITH SOAP AND WATER BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES. MIXED MATERIALS CONTAIN THE HAZARDS OF ALL THE COMPONENTS, THEREFORE, READ THE MSDS'S OF ALL THE COMPONENTS PRIOR TO USING MATERIAL. PROPERLY LABEL ALL CONTAINERS.
OTHER PRECAUTIONS
AVOID ALL SKIN CONTACT. AVOID BREATHING VAPORS GENERATED FROM THE MATERIAL. OBSERVE CONDITIONS OF GOOD GENERAL HYGIENE AND SAFE WORKING PRACTICES. CONTAMINATED LEATHER ARTICLES CANNOT BE CLEANED AND MUST BE DISCARDED IF CONTAMINATED WITH THIS PRODUCT. WASH ALL CONTAMINATED CLOTHING PRIOR TO THE REUSE THEREOF.
WEAR RESPIRATOR AND PROTECTIVE CLOTHING. SHUT OFF THE SOURCE AT THE LEAK, REMOVE EXCESS WITH VACCUM TRUCK AND TAKE UP THE REMAINDER WITH AN ABSORBANT SUCH AS CLAY AND PLACE IN DISPOSAL CONTAINERS. FLUSH AREA WITH WATER TO REMOVE RESIDUE.
WASTE DISPOSAL METHOD
DISPOSE OF THE MATERIAL IN A WASTE DISPOSAL SITE IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL LAWS.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
STORE IN COOL DRY PLACE. SEAL ALL PARTIALLY USED CONTAINERS, WASH WITH SOAP AND WATER BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES. MIXED MATERIALS CONTAIN THE HAZARDS OF ALL THE COMPONENTS, THEREFORE, READ THE MSDS'S OF ALL THE COMPONENTS PRIOR TO USING MATERIAL. PROPERLY LABEL ALL CONTAINERS.
OTHER PRECAUTIONS
AVOID ALL SKIN CONTACT. AVOID BREATHING VAPORS GENERATED FROM THE MATERIAL. OBSERVE CONDITIONS OF GOOD GENERAL HYGIENE AND SAFE WORKING PRACTICES. CONTAMINATED LEATHER ARTICLES CANNOT BE CLEANED AND MUST BE DISCARDED IF CONTAMINATED WITH THIS PRODUCT. WASH ALL CONTAMINATED CLOTHING PRIOR TO THE REUSE THEREOF.
SECTION VIII -- CONTROL MEASURES
RESPIRATORY PROTECTION
USE A NIOSH APPROVED RESPIRATOR AS REQUIRED TO PREVENT OVER-EXPOSURE TO VAPOR IN ACCORDANCE WITH 29 CF2 1910, 134. GENERAL EXHAUST IS USUALLY SUFFICIENT IN THE LIEU OF NIOSH RESPIRATOR.
VENTILATION
GENERAL EXHAUST IS USUALLY SUFFICIENT TO CONTROL VAPORS AND EXPOSURE HAZARDS.
PROTECTIVE GLOVES
IMPERVIOUS GLOVES - NEOPRENE OR RUBBER
EYE PROTECTION
SPLASH PROOF GOGGLES OR GLASSES WITH SIDE SHIELDS.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT
WEAR BODY COVERING CLOTHING AND OTHER COVERINGS AS NECESSARY SUCH AS APRON AND APPROPRIATE FOOTWEAR TO AVOID CONTACT WITH MATERIAL.
WORK/HYGIENIC PRACTICES
OBSERVE GOOD GENERAL HYGIENIC PRACTICES.
USE A NIOSH APPROVED RESPIRATOR AS REQUIRED TO PREVENT OVER-EXPOSURE TO VAPOR IN ACCORDANCE WITH 29 CF2 1910, 134. GENERAL EXHAUST IS USUALLY SUFFICIENT IN THE LIEU OF NIOSH RESPIRATOR.
VENTILATION
GENERAL EXHAUST IS USUALLY SUFFICIENT TO CONTROL VAPORS AND EXPOSURE HAZARDS.
PROTECTIVE GLOVES
IMPERVIOUS GLOVES - NEOPRENE OR RUBBER
EYE PROTECTION
SPLASH PROOF GOGGLES OR GLASSES WITH SIDE SHIELDS.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT
WEAR BODY COVERING CLOTHING AND OTHER COVERINGS AS NECESSARY SUCH AS APRON AND APPROPRIATE FOOTWEAR TO AVOID CONTACT WITH MATERIAL.
WORK/HYGIENIC PRACTICES
OBSERVE GOOD GENERAL HYGIENIC PRACTICES.
SECTION IX -- DISCLAIMER
DISCLAIMER
THE INFORMATION CONTAINED HEREIN IS BASED ON THE DATA AVAILABLE TO US AND IS BELIEVED TO BE ACCURATE. HOWEVER, N.I.F. MAKES NO WARRANTY EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THIS DATA OR THE RESULTS OBTAINED FROM THE USE THEREOF. N.I.F. ASSUMES NO RESPONSIBILITIES FOR INJURY FROM THE USE OF THIS PRODUCT.
THE INFORMATION CONTAINED HEREIN IS BASED ON THE DATA AVAILABLE TO US AND IS BELIEVED TO BE ACCURATE. HOWEVER, N.I.F. MAKES NO WARRANTY EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THIS DATA OR THE RESULTS OBTAINED FROM THE USE THEREOF. N.I.F. ASSUMES NO RESPONSIBILITIES FOR INJURY FROM THE USE OF THIS PRODUCT.