DURA-GLAZE #4, PART B
PRODUCT NAME: DURA-GLAZE #4, PART B
HMIS CODES: H F R P
PRODUCT CODE: EPOXY RESIN 1 1 0 G
HMIS CODES: H F R P
PRODUCT CODE: EPOXY RESIN 1 1 0 G
SECTION I -- MANUFACTURER IDENTIFICATION
MANUFACTURER'S NAME: NORTHERN INDUSTRIAL FLOORING, INC.
ADDRESS: 8140 W 350 N ANGOLA, IN 46703
EMERGENCY PHONE: CHEMTREC 800-424-9300
INFORMATION PHONE: 800-424-8914
DATE REVISED: 01-01-97 NAME OF PREPARER: HARRY JACKSON
ADDRESS: 8140 W 350 N ANGOLA, IN 46703
EMERGENCY PHONE: CHEMTREC 800-424-9300
INFORMATION PHONE: 800-424-8914
DATE REVISED: 01-01-97 NAME OF PREPARER: HARRY JACKSON
SECTION II -- HAZARDOUS INGREDIENTS/SARA III INFORMATION
OCCUPATIONAL EXPOSURE LIMITS
HAZARDOUS COMPONENTS CAS NUMBER % OSHA PEL ACGI TLV
-------------------------------------------------------------------------------------------
DIGLYCIDYL ETHER BISPHENOL
A EPOXY RESIN 25085-99-8 75-87 N.E. *1 N.E.
ALIPHATIC GLYCIDYL ETHER
DILUENT 68609-97-2 13-25 N.E. N.E.
*NOTE 1 -- N.E. = None Established
T.S.C.A. Status -- O.K. on all above components.
HAZARDOUS COMPONENTS CAS NUMBER % OSHA PEL ACGI TLV
-------------------------------------------------------------------------------------------
DIGLYCIDYL ETHER BISPHENOL
A EPOXY RESIN 25085-99-8 75-87 N.E. *1 N.E.
ALIPHATIC GLYCIDYL ETHER
DILUENT 68609-97-2 13-25 N.E. N.E.
*NOTE 1 -- N.E. = None Established
T.S.C.A. Status -- O.K. on all above components.
SECTION III -- PHYSICAL/CHEMICAL CHARACTERISTICS
BOILING POINT: N/A SPECIFIC GRAVITY (H2O=1): higher than 1
VAPOR DENSITY: N/A EVAPORATION RATE: N/A
SOLUBILITY IN WATER: NONE MELTING POINT: N/A
VAPOR PRESSURE: N/A
APPEARANCE AND ODOR: VISCOUS LIQUID. MILD CHARACTERISTIC ODOR.
VAPOR DENSITY: N/A EVAPORATION RATE: N/A
SOLUBILITY IN WATER: NONE MELTING POINT: N/A
VAPOR PRESSURE: N/A
APPEARANCE AND ODOR: VISCOUS LIQUID. MILD CHARACTERISTIC ODOR.
SECTION IV -- FIRE AND EXPLOSION HAZARD DATA
FLASH POINT: 485EF
FLAMMABLE LIMITS IN AIR BY VOLUME - LOWER: N/A UPPER: N/A
EXTINGUISHING MEDIA: FOAM, CO2, DRY CHEMICAL, WATER SPRAY.
SPECIAL FIREFIGHTING PROCEDURES: FIRE FIGHTERS SHOULD WEAR FULL EMERGENCY EQUIPMENT WITH SELF-CONTAINED BREATHING APPARATUS.
UNUSUAL FIRE AND EXPLOSION HAZARDS: COMBUSTION PRODUCTS MAY BE TOXIC. COOL STORAGE CONTAINERS WITH WATER SPRAY TO PREVENT PRESSURE BUILD-UP THAT MAY RUPTURE THE CONTAINERS.
FLAMMABLE LIMITS IN AIR BY VOLUME - LOWER: N/A UPPER: N/A
EXTINGUISHING MEDIA: FOAM, CO2, DRY CHEMICAL, WATER SPRAY.
SPECIAL FIREFIGHTING PROCEDURES: FIRE FIGHTERS SHOULD WEAR FULL EMERGENCY EQUIPMENT WITH SELF-CONTAINED BREATHING APPARATUS.
UNUSUAL FIRE AND EXPLOSION HAZARDS: COMBUSTION PRODUCTS MAY BE TOXIC. COOL STORAGE CONTAINERS WITH WATER SPRAY TO PREVENT PRESSURE BUILD-UP THAT MAY RUPTURE THE CONTAINERS.
SECTION V -- REACTIVITY DATA
STABILITY: STABLE
CONDITIONS TO AVOID
EXCESS OVER LONG PERIODS OF TIME DEGRADES THE RESIN.
INCOMPATIBILITY (MATERIALS TO AVOID)
UNCONTROLLED REACTION WITH AMINES.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS
BY FIRE -- CARBON MONOXIDE, CARBON DIOXIDE, NITROGEN OXIDE, ALDEHYDES.
HAZARDOUS POLYMERIZATION : WILL NOT OCCUR
UNCONTROLLED REACTION WITH AMINES.
NOTE:
PERSONS WITH LUNG DISORDERS OR WHO ARE SENSITIZED SHOULD NOT USE THIS PRODUCT.
CONDITIONS TO AVOID
EXCESS OVER LONG PERIODS OF TIME DEGRADES THE RESIN.
INCOMPATIBILITY (MATERIALS TO AVOID)
UNCONTROLLED REACTION WITH AMINES.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS
BY FIRE -- CARBON MONOXIDE, CARBON DIOXIDE, NITROGEN OXIDE, ALDEHYDES.
HAZARDOUS POLYMERIZATION : WILL NOT OCCUR
UNCONTROLLED REACTION WITH AMINES.
NOTE:
PERSONS WITH LUNG DISORDERS OR WHO ARE SENSITIZED SHOULD NOT USE THIS PRODUCT.
SECTION VI -- HEALTH HAZARD DATA
ROUTES OF ENTRY: INHALATION - YES SKIN - YES INGESTION - YES
SIGNS AND SYMPTOMS OF EXPOSURE: IRRITATION OF SKIN
HEALTH HAZARDS (ACUTE AND CHRONIC)
ACUTE: IRRITATION OF SKIN AND DERMATITIS.
CHRONIC: REPEATED OVEREXPOSURE WILL CAUSE SEVERE SKIN IRRITATION, DERMATITIS AND SENSITIZATION. SENSITIZED
PERSONS MAY EXPERIENCE RAPID IRRITATION OF SKIN UPON EXPOSURE.
CARCINOGENICITY: NTP? NO IARC MONOGRAPHS? NO OSHA REGULATED? NO
NO LISTED INGREDIENTS OF THIS PRODUCT ARE REGULATED AS CARCINOGENS.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE
ALLERGY, SKIN DISORDERS
EMERGENCY AND FIRST AID PROCEDURES
EYES: FLUSH WITH WATER, HOLDING LIDS OPEN FOR FIFTEEN MINUTES OR MORE. CALL PHYSICIAN FOR ADVICE IF
NECESSARY.
SKIN: PROMPTLY WASH WITH SOAP AND WATER. DO NOT WASH WITH SOLVENTS. SEEK MEDICAL ADVICE IF IRRITATION
DEVELOPS OR PERSISTS.
INHALATION: MOVE PERSON TO FRESH AREA IF EFFECTS OCCUR. IF NEEDED, GIVE OXYGEN OR ARTIFICIAL RESPIRATION TO
IMPROVE BREATHING. CONSULT PHYSICIAN.
INGESTION: GET MEDICAL ATTENTION IMMEDIATELY. NEVER GIVE LIQUIDS TO AN UNCONSCIOUS OR CONVULSING PERSON.
SIGNS AND SYMPTOMS OF EXPOSURE: IRRITATION OF SKIN
HEALTH HAZARDS (ACUTE AND CHRONIC)
ACUTE: IRRITATION OF SKIN AND DERMATITIS.
CHRONIC: REPEATED OVEREXPOSURE WILL CAUSE SEVERE SKIN IRRITATION, DERMATITIS AND SENSITIZATION. SENSITIZED
PERSONS MAY EXPERIENCE RAPID IRRITATION OF SKIN UPON EXPOSURE.
CARCINOGENICITY: NTP? NO IARC MONOGRAPHS? NO OSHA REGULATED? NO
NO LISTED INGREDIENTS OF THIS PRODUCT ARE REGULATED AS CARCINOGENS.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE
ALLERGY, SKIN DISORDERS
EMERGENCY AND FIRST AID PROCEDURES
EYES: FLUSH WITH WATER, HOLDING LIDS OPEN FOR FIFTEEN MINUTES OR MORE. CALL PHYSICIAN FOR ADVICE IF
NECESSARY.
SKIN: PROMPTLY WASH WITH SOAP AND WATER. DO NOT WASH WITH SOLVENTS. SEEK MEDICAL ADVICE IF IRRITATION
DEVELOPS OR PERSISTS.
INHALATION: MOVE PERSON TO FRESH AREA IF EFFECTS OCCUR. IF NEEDED, GIVE OXYGEN OR ARTIFICIAL RESPIRATION TO
IMPROVE BREATHING. CONSULT PHYSICIAN.
INGESTION: GET MEDICAL ATTENTION IMMEDIATELY. NEVER GIVE LIQUIDS TO AN UNCONSCIOUS OR CONVULSING PERSON.
SECTION VII -- PRECAUTIONS FOR SAFE HANDLING AND USE
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED
WEAR PROTECTIVE EQUIPMENT T PREVENT EXPOSURE. STOP SPILL AND DIKE TO PREVENT SPREADING. COVER SPILL WITH ABSORBENT MATERIALS AND COLLECT INTO CONTAINERS. CLEAN CONTAMINATED AREA WITH DETERGENT AND WATER OR A STEAM CLEANER FOR BEST RESULTS.
WASTE DISPOSAL METHOD
DISPOSE IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL REQUIREMENTS.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE.
OTHER PRECAUTIONS: NONE KNOWN.
WEAR PROTECTIVE EQUIPMENT T PREVENT EXPOSURE. STOP SPILL AND DIKE TO PREVENT SPREADING. COVER SPILL WITH ABSORBENT MATERIALS AND COLLECT INTO CONTAINERS. CLEAN CONTAMINATED AREA WITH DETERGENT AND WATER OR A STEAM CLEANER FOR BEST RESULTS.
WASTE DISPOSAL METHOD
DISPOSE IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL REQUIREMENTS.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE.
OTHER PRECAUTIONS: NONE KNOWN.
SECTION VIII -- CONTROL MEASURES
RESPIRATORY PROTECTION
PROVIDE ADEQUATE EXHAUST VENTILATION AND/OR NIOSH APPROVED AMINE CARTRIDGE RESPIRATOR.
VENTILATION
LOCAL EXHAUST: IF NEEDED.
SPECIAL: NONE KNOWN.
MECHANICAL: ADEQUATE EXHAUST VENTILATION MUST EXHAUST AWAY FROM APPLICATOR.
PROTECTIVE GLOVES
NATURAL RUBBER OR NEOPRENE GLOVES
EYE PROTECTION
SPLASH GOGGLES OR FACE SHIELD.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT
USE RUBBER APRON, FACE SHIELD AND APPROPRIATE CLOTHING TO PREVENT CONTACT WITH SKIN. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. DISCARD CONTAMINATED LEATHER SHOES AND CANVAS SNEAKERS. PROTECTIVE SKIN CREAMS HELP CLEANING WITH SOAP AND WATER, GLOVES MUST STILL BE WORN. AN EYE WASH STATION OR AN ADEQUATE SUPPLY OF CLEAN WATER MUST BE AVAILABLE AT WORK AREAS.
WORK/HYGIENIC PRACTICES
ENFORCE CAREFUL HANDLING TO PREVENT SPLASHING. WASH THOROUGHLY
PROVIDE ADEQUATE EXHAUST VENTILATION AND/OR NIOSH APPROVED AMINE CARTRIDGE RESPIRATOR.
VENTILATION
LOCAL EXHAUST: IF NEEDED.
SPECIAL: NONE KNOWN.
MECHANICAL: ADEQUATE EXHAUST VENTILATION MUST EXHAUST AWAY FROM APPLICATOR.
PROTECTIVE GLOVES
NATURAL RUBBER OR NEOPRENE GLOVES
EYE PROTECTION
SPLASH GOGGLES OR FACE SHIELD.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT
USE RUBBER APRON, FACE SHIELD AND APPROPRIATE CLOTHING TO PREVENT CONTACT WITH SKIN. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. DISCARD CONTAMINATED LEATHER SHOES AND CANVAS SNEAKERS. PROTECTIVE SKIN CREAMS HELP CLEANING WITH SOAP AND WATER, GLOVES MUST STILL BE WORN. AN EYE WASH STATION OR AN ADEQUATE SUPPLY OF CLEAN WATER MUST BE AVAILABLE AT WORK AREAS.
WORK/HYGIENIC PRACTICES
ENFORCE CAREFUL HANDLING TO PREVENT SPLASHING. WASH THOROUGHLY
SECTION IX -- DISCLAIMER
DISCLAIMER
THE INFORMATION CONTAINED HEREIN IS BASED ON THE DATA AVAILABLE TO US AND IS BELIEVED TO BE ACCURATE. HOWEVER, N.I.F. MAKES NO WARRANTY EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THIS DATA OR THE RESULTS OBTAINED FROM THE USE THEREOF. N.I.F. ASSUMES NO RESPONSIBILITIES FOR INJURY FROM THE USE OF THIS PRODUCT.
THE INFORMATION CONTAINED HEREIN IS BASED ON THE DATA AVAILABLE TO US AND IS BELIEVED TO BE ACCURATE. HOWEVER, N.I.F. MAKES NO WARRANTY EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THIS DATA OR THE RESULTS OBTAINED FROM THE USE THEREOF. N.I.F. ASSUMES NO RESPONSIBILITIES FOR INJURY FROM THE USE OF THIS PRODUCT.